Component failure故障部件車輛|挖掘機維修,挖掘機修理,維修挖掘機,修理挖掘機
 112        Accelerator Pedal 1 Failure         加速踏板1故障
113        Accelerator Pedal /Brake Plausibility        加速踏板與制動踏板信號不可信
116        Main Clutch Signal Failure        離合信號故障
117        Brake Signal Failure        制動踏板故障
119        Terminal 15 Failure        15 端子故障
11C        Water in Fuel        燃油濾清器儲水器
211        Vehicle Speed Sensor Failure        車速傳感器故障
215        Cruise Control Buttons Irreversible        巡航控制按扭不可逆故障
315        Cruise Control Buttons Reversible Failure        巡航控制開關可逆故障
 車輛2(繼電器/執行器)
125        Main Relay 2 Failure        主繼電器2失效
126        Battery Voltage Failure        蓄電池電壓故障
127        Engine Brake decompression Valve failure        發動機制動失效
128        Main Relay 1-Short Circuit To Battery        主繼電器1與電池短路
129        Main Relay 3 Failure        主繼電器3故障
12A        Thermostarter Relay 1(Heater)        發動機制動(主繼電器4)故障
12B        Air Heater 1 Power Stage Failure        空氣加熱器1 Power Stage 故障
12E        Pre-Post Heating Control System (Active)        預加熱控制系統故障
225        Main Relay failure (Interrupted Afterrun)        主繼電器失效(停機后中斷)
228        Main Relay 1 (High Pressure Pump) Short to Ground        主繼電器1對地短路
 發動機1(溫度和壓力傳感器)
131        Coolant Temperature Sensor failure        冷卻液溫度傳感器
132        Coolant Temperature Dynamic failure        冷卻液溫度傳感器動態故障
133        Boost Air Temperature Sensor failure        進氣溫度傳感器
134        Boost Pressure Sensor failure        進氣壓力傳感器
135        Fuel Temperature Sensor failure        燃油溫度傳感器
136        Rail Pressure Sensor failure        共軌壓力傳感器
137        Common Rail Pressure Limiting Valve failure        共軌壓力限壓閥
138        Oil Pressure Sensor failure        機油壓力傳感器
13A        Oil Temperature Sensor failure        機油溫度傳感器
232        Coolant Temperature Test failure        冷卻液溫度(監測)
236        Rail Pressure Sensor Offset Monitoring        共軌壓力傳感器偏差監測
238        Oil Pressure too low        機油壓力過低
23A        Oil Temperature too high        機油溫度過高
 發動機2(轉速傳感器/執行器)
141        Crankshaft Speed Signal failure        曲軸轉速傳感器
142        Engine runs with Camshaft Speed only        只有凸輪軸傳感器信號
143        Camshaft Speed Signal failure        凸輪軸傳感器
144        Offset between Camshaft and Crankshaft        凸輪軸傳感器和曲軸傳感器信號偏差超出限值
149        Filter Heater failure        燃油濾芯加熱器故障
14A        Engine Compartment Start Button stuck        發動機機艙啟動按鈕發卡
14D        Info: Engine Overspeed Protection        提示:發動機超速保護
24A        Engine Compartment Stop Button stuck        發動機機艙停止按鈕發卡
 共軌系統燃油計量
152        Rail Pressure Positive Deviation High and High Fuel Flow Setpoint Value        共軌壓力正偏差過高和燃油流量設定值過高
153        Rail Pressure Negative Deviation too High on Minimum Metering        共軌壓力負偏差過高(小流量)
154        Rail Pressure below Minimum Limit in Controlled Mode        共軌壓力低于小極限
155        Rail Pressure above Maximum Limit in Controlled Mode        共軌壓力大于大極限
156        Rail Pressure Drop Rate too High        共軌燃油壓力下降率太高
157        Setpoint of Rail Metering Unit not plausible in Overrun        超速時共軌計量閥不真實
158        Fuel Flow Setpoint of Common Rail Metering Unit too low        共軌計量裝置燃油流量設置點過低
159        Common Rail Metering Unit Power Stage failure        共軌油泵計量閥Power Stage 故障
259        Common Rail Metering Unit Power Stage Short to Battery        共軌計量閥正極短路
359        Common Rail Metering Unit Power Stage Short to Ground        共軌計量閥負極短路
 噴油器1
 161        Injector Cylinder 1 failure        第1缸噴油器故障
162        Injector Cylinder 2 failure        第2缸噴油器故障
163        Injector Cylinder 3 failure        第3缸噴油器故障
164        Injector Cylinder 4 failure        第4缸噴油器故障
165        Injector Cylinder 5 failure        第5缸噴油器故障
166        Injector Cylinder 6 failure        第6缸噴油器故障
167        Injector Cylinder 1 warning         第1缸噴油器開路
168        Injector Cylinder 2 warning         第2缸噴油器開路
169        Injector Cylinder 3 warning        第3缸噴油器開路
16A        Injector Cylinder 4 warning        第4缸噴油器開路
16B        Injector Cylinder 5 warning        第5缸噴油器開路
16C        Injector Cylinder 6 warning        第6缸噴油器開路
16E        Minimum Injections Number not reached        未達到少的噴射缸數
 噴油器2
 171        Injector Bank 1 failure        噴油器排線1故障
172        Injector Bank 2 failure        噴油器排線2故障
17C        ECU Hardware for Injection: CY33X Chip specific failure (1)        ECU的噴油器控制裝置:CY33X(1)故障
27C        ECU Hardware for Injection: CY33X Chip specific failure (2)        ECU的噴油器控制裝置:CY33X(2)故障
 增壓系統和渦輪機轉速
19E        Torque Reduction due to Smoke Limitation        限制扭矩值,以減少煙量
29D        Info: Torque Limitation due to Negative Torque Coordinator        提示:因為有負扭矩產生了扭矩限制
39E        Info: Torque Limitation due to Turbo Charger Protection        提示:因為增壓器保護產生了扭矩限制
49E        Info: Torque Limitation due to Engine Protection (against Excessive Torque, Engine Overspeed and Overheat)        提示:由于發動機的保護對扭矩進行了限制
69E        Info: Torque Limitation due to Fuel Quantity Limitation because of Injection System Errors        提示:由于噴油系統的噴油量進行了限制,對扭矩進行限制
 接口1(CAN-Bus 總線)
1B1        CAN A Bus off        CAN A 關閉
1B2        CAN B Bus off        CAN B 關閉
1B3        CAN C Bus off        CAN控制器 C 關閉
1B4        CAN Message timeout BC2EDC1 (from Body Computer)        CAN信息BC2EDC1超時
1B7        CAN Transmit Message timeout        CAN傳輸信息超時
2B4        CAN Message timeout BC2EDC2 (from Body Computer)        CAN 信息 BC2EDC2超時
1C3        CAN Message timeout TCO1 (from Tachograph Output)        CAN信息TCO1超時
ECU1(內部檢查)
1D1        ECU Hardware:  SPI Communication failure        ECU硬件:SPI通訊故障
1D2        ECU Hardware:  EEPROM failure        ECU硬件:存儲器故障
1D3        ECU recovery – locked        ECU恢復-鎖定
1D4        ECU Hardware: Microcontroller Watchdog failure        EDC硬件:微處理器監視器故障
1D5        ECU Hardware: Shut off during Initialization        ECU硬件:初始化故障
1D6        ECU Hardware: TPU Monitoring        ECU硬件:TPU監視
1D7        ECU Software: Variant Dataset failure         ECU軟件:程序故障
1D8        Overrun Monitoring failure        超速監控故障
1D9        Redundant Engine Speed in Overrun Monitoring        備用發動機速度監控故障
2D3        ECU recovery - suppressed        ECU恢復-禁止
3D3        ECU recovery - visible        ECU恢復-可見
ECU2(動力起動/靜止/超速/傳感器電源)
1E1        ECU Hardware: High Side Power Stage Short to Ground or Battery        ECU故障:高 Power Stage 對地短路或對電池短路
1E2        Immobilizer failure (no fuel release)        防盜器故障(無燃油噴射)
1E3        Overrun Monitoring failure        超速監控故障
1E4        Redundant Engine Speed in Overrun Monitoring        備用發動機速度監控故障
1E5        ECU Hardware: Sensor 12V Supply Voltage failure        ECU硬件:12V電源電壓故障
1E6        ECU Hardware: Sensor Supply Voltage 1 failure        ECU硬件:傳感器1電源
1E7        ECU Hardware: Sensor Supply Voltage 2 failure        EDC硬件:傳感器電源2故障
1E8        ECU Hardware: Sensor Supply Voltage 3 failure        EDC硬件:傳感器電源3故障
1E9        ECU internal Supply Voltage too high        ECU內部電源電壓過高
1EA        ECU internal Supply Voltage too low        ECU內部電源電壓過低
1EB        Atmospheric Pressure Sensor failure        大氣壓力傳感器
2E1        ECU Hardware: Low Side Power Stage Short to Ground or Battery        ECU硬件:低Power Stage 對地短路或電池短路挖掘機技術故障與師傅進行溝通交流，官方網站http://www.sxhtls.com修理直撥:0551-64493367  服務專線:13956953738